Tell us about the job
Takes about a minute. No obligation.
Sizing a furnace for a Robertson County home is a local calculation, and the weather record is part of what makes it local. 187 severe weather events were recorded in Robertson County, Tennessee between 2015 and 2024. At that rate, severe weather is a standing condition of operating here, which means a contractor selecting and installing equipment has to account for what the system will be running against season after season. A unit sized by generic regional tables, without that load factored in, leaves the homeowner with equipment that works harder than it was specced to handle.
Existing ductwork in a house this age was designed around a different generation of equipment, and a new furnace rarely inherits it without adjustment. Half the homes in Robertson County, Tennessee were built in 1994 or earlier (2020-2024 ACS 5-year). What that means for an installation is that a contractor has to measure what the ducts will actually carry before the new unit is ever priced, because the gap between what was built and what now runs is where the job either works or does not. Electrical service in houses of that vintage can present the same question. The ductwork answer comes first.
What Gets Installed With a New Furnace
The furnace itself sits in the basement, utility closet, or crawlspace and is the unit that generates heat. A contractor mounts the air handler or blower assembly inside it, which pushes conditioned air out through the supply side of the house. The flue pipe runs from the furnace up and out of the structure, carrying combustion gases away.
The thermostat mounts on an interior wall and is the control point the homeowner sees and uses every day. A contractor also installs or connects the filter housing at the air intake, which is where return air enters the system before it reaches the furnace cabinet. On high-efficiency models, a secondary condensate drain line runs to a nearby floor drain or pump.
The drawing shows a general layout of these components, and a licensed contractor determines exactly what applies to your house and its existing setup.
Find a contractor in Robertson CountyRobertson County, by the numbers
187 severe weather events were recorded in Robertson County, Tennessee between 2015 and 2024.
NOAA National Centers for Environmental Information, Storm Events Database, bulk CSV export, events 2015-01-01 through 2024-12-31.Half the homes in Robertson County, Tennessee were built in 1994 or earlier (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesRobertson County, Tennessee holds 29,824 housing units (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesOwners occupy 77.6% of the occupied homes in Robertson County, Tennessee (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesCodes & Standards Behind Furnace Installation in Robertson County, Tennessee5 sourced rules and standards
What the Installation Looks Like
Non-weatherized gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized oil-fired furnaces manufactured on or after November 19, 2015 must reach 83.0 percent AFUE.
Mobile home gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized gas furnaces manufactured on or after December 18, 2028 must reach 95.0 percent AFUE, up from the 80.0 percent minimum that applies to units manufactured before that date.
Licensing Rules for Robertson County, Tennessee
Tennessee licenses contractors by classification, and HVAC, refrigeration and gas piping is one of them — a sub-classification of mechanical contracting on the licence the Board for Licensing Contractors issues.
Severe Weather History in Robertson County
Weather patterns in Robertson County put real demands on heating equipment over the course of its life. A furnace sized and installed for local conditions handles those demands better than one that was not.
187 severe weather events, 2015–2024. Source: NOAA National Centers for Environmental Information, Storm Events Database.